Description：
Type:A/C Compressor
1 Year Warranty
Direct Replacement
Voltage: 12V
Compressor Type: TRSA09
Oil Type: PAG 100
Pulley Groove Quantity: 6
Clutch Included: Yes
Pulley Included: Yes
R-efrigerant Type: R-134a
Placement on Vehicle: Front
OE Number:
CO 4914AC, 2004914, 0610061, 2004914AM, 6511266, 3657
38800PLMA021M2, 38810PLMA12, 4914, 4973, 4978, 4980
4984, 4985,38810PLMA11, 38810PLMA11RM, 38810PLMA12RM
Application For :
For Honda Civic 2002-2005 L4 1.7L
Package include:
1× A/C Compressor +Clutch
Installation Method:
Attention Please:
Be sure to clean the air conditioning system before installation, otherwise it will cause compression broken.
1. Remove compressor:
Remove the A/C belt from the A/C compressor pulley. May involve loosening the belt tensioner (if equipped).
2.receiver drier or accumulator, orifice tube or expansion valve.
3.Disconnect the negative battery cable.
4.Remove the bolt that secures refrigerant lines to the A/C compressor. Inspect A/C lines for any contamination such as metal or excessive dirt inside of them. If you find any
contamination the system will need to be cleaned.Flush the condenser and evaporator using NON-OIL BASED A/C flush. On expansion valve systems. The valve must be removed before
the evaporator can be flushed. Flushed condensers from outlet to inlet and evaporators from inlet to outlet.
5.Drain all the oil from the new compressor ,if you compressor has a drain plug you will need to open it up and drain what oil is in there too.
6.Install half oil charge into the compressor and the remainder throughout the system. Turn compressor shaft 8-10 full revolutions to insure front seal and other internal
parts are lubricated.
7.Install new receiver drier or accumulator and new orifice tube or expansion valve.
8.Evacuate the A/C system for a minimum of one hour.
9.After evacuation install half the refrigerant charge and let the system set for 1 minute. This will allow the refrigerant to pick up oil and spread more evenly throughout
the system.
10.Turn on the A/C system with the engine running and check to see if cold air is now coming out of the air duct.
11.If the A/C system is functioning ,you may find that your electric radiator fan and compressor clutch will be cycling off and on depending on the outside air temperature.
To confirm that this part fits your vehicle, enter your vehicle's Year, Make, Model, Trim and Engine in the Compatibility Table.
Notes:
1.We strongly recommend professional installation.
2.please make sure the installation site is clean. Or, it will cause operating obstruction,even make the temperature of the compressor very high, and the belt on the clutch may melt.
3.Before installing the air conditioning compressor, clean the vehicle pipe to avoid noise and non-working problems.
4.Each air conditioner compressor is equipped with oil, does not need additional refueling, directly installed, add about 70-80% refrigerant can be used,There may be noise if the refrigerant is added too much.
